|
1999-2004 Engine Fastener Torque specs
Directly from General Motors:
Inch pounds are highlighted
- Accelerator Control Cable Bracket Bolt: 89 in lbs
- Air Injection Check Valve (Cali emissions): 15 ft lb
- Air Injection Check Valve front bracket Bolt and Nut (cali emissions): 18 ft lbs
- Air Injection Valve Nut(Cali emssions): 89 in lbs
- Air Injection valve pipe adapter: 22 ft lbs
- Air Injection check valve rear bracket nuts (Cali emissions) 18 ft lbs
- Air injection solenoid bolt(Cali emissions): 89 in lbs
- Camshaft Position Sensor bolt: 89 in lbs
- Camshaft Spocket bolt: 103 ft lbs
- Camshaft Thrust Plate Screw: 89 in lbs
- Conncetion Rod Bearing Cap Nut: 15 ft lbs + 75*
- Coolant Drain Plug: 14 ft lbs
- Coolant Temperature Sensor: 17 ft lbs
- Crankshaft Balancer Bolt: 76 ft lbs
- Crankshaft Main Bearing Cap Bolt/Stud: 37 ft lbs + 77*
- Crankshaft Oil Deflector Nut: 18 ft lbs
- Crankshaft Position Sensor Bolt-Front Cover: 89 in lbs
- Crankshaft Position Sensor Stud-Side of block: 98 in lbs
- Crankshaft Position Sensor Wiring Bracket bolt: 37 ft lbs
- Cylinder Head Bolt: 37 ft lbs + 90*
- Drive Belt Shield Bolt: 89 in lbs
- Drive Belt Tensioner Bolt: 37 ft lbs
- EGR Valve to EGR Valve Pipe Bolt: 18 ft lbs
- EGR Valve Adapter Pipe to Exhaust Manifold Nut: 18 ft lbs
- Engine Fly Wheel Bolt: 52 ft lbs
- Engine Front Cover Bolt-Large: 41 ft lbs
- Engine Front Cover Bolt-Medium: 35 ft lbs
- Engine Front Cover Bolt-Small: 15 ft lbs
- Engine Mount Bracket Bolt: 43 ft lbs
- Engine Mount Lower Nut: 32 ft lbs
- Engine Mount Strut and lift Bracket Bolt-Engine Left Rear: 52 ft lbs
- Engine Mount Strut Bolt/Nut: 35 ft lbs
- Engnie Mount Strut Bracket Bolt-Upper Radiator Support: 21 ft lbs
- Engine Mount Strut Bracket Bolt-Vehicle Right Side: 37 ft lbs
- Engine Mount Upper Nut: 35 ft lbs
- Engine Oil Pressure Indicator Switch: 115 in lbs
- Engine Wiring Harness Bracket Bolt: 115 in lbs
- Exhaust Crossover Pipe Heat Shield Bolt: 89 in lbs
- Exhaust Crossover Pipe Nut: 18 ft lbs
- Exhaust Manifold Hest Shield Bolt: 89 in lbs
- Exhaust Manifold Nut: 12 ft lbs
- Exhaust Manifold Stud: 13 ft lbs
- Fuel Feed Pipe to Fuel Injector Rail Nut: 13 ft lbs
- Fuel Injector Rail Bolt: 89 in lbs
- Fuel Pipe Bracket Bolt/Stud: 37 ft lbs
- Fuel Pipe Clip Bolt: 71 in lbs
- Fuel Return Pipe to Fuel Injector Rail Nut: 13 ft lbs
- Generator Bracket and Front Engine Lift hook Bolt: 37 ft lbs
- Heated Oxygen Sensor: 31 ft lbs
- Heater Inlet pipe Nut: 18 ft lbs
- Ingition Coil Bracket Bolt/Nut/Stud: 18 ft lbs
- Intake Manifold Coolant Pipe Bolt: 89 in lbs
- Knock Sensor: 14 ft lbs
- Lower Intake Manifold Boilt: 115 in lbs
- MAP Sensor Bolt: 44 in lbs
- Oil Cooler Connector: 37 ft lbs
- Oil Cooler Hose Fitting: 14 ft lbs
- Oil Cooler Pipe Bracket Bolt: 89 in lbs
- Oil Filter: 115 in lbs
- Oil Filter Bypass Hole Plug: 14 ft lbs
- Oil Filter Fitting: 29 ft lbs
- Oil Galley Plug-1/4 inch: 14 ft lbs
- Oil Galley Plug-3/8 inch: 24 ft lbs
- Oil Level Indictor Tube Bolt: 18 ft lbs
- Oil Level Sensor Bolt: 89 in lbs
- Oil Pan Bolt: 18 ft lbs
- Oil Pan Drain Plug: 18 ft lbs
- Oil Pan Side Bolt: 37 ft lbs
- Oil Pump Cover Bolt: 89 in lbs
- Oil Pump Drive Clamp Bolt: 27 ft lbs
- Oil Pump Mounting bolt: 30 ft lbs
- Spark Plug: 20 ft lbs
- Thermostat Bypass Pipe to Cylinder Head Nut: 18 ft lbs
- Thermostat Bypass Pipe to Engine Front Cover Bolt: 106 in lbs
- Thermostat Bypass Pipe to throttle Body Nut: 18 ft lbs
- Throttle Body Bolt/Stud: 18 ft lbs
- Timing Chain Dampener Bolt: 15 ft lbs
- Transaxle-to-Engine Bolts: 55 ft lbs
- Upper Intake Manifold Bolt/Stud: 18 ft lbs
- Valve Lifter guide Bolt: 89 in lbs
- Valve Rocker Arm Bolt: 14 ft lbs + 30*
- Valve Rocker Arm Cover Bolt: 89 in lbs
- Water Outlet Bolt: 18 ft lbs
- Water Pump Bolt: 89 in lbs
- Water Pump Pulley Bolt: 18 ft lbs
__________________
33% ALEROMOD OWNER!!
2000 Olds Alero 3400 SFI 14.53 @ 94.93
1985 Olds Delta 88 307 SBO 17.96 @ 76.99
2007 Volvo V50 T5 6M 15.782 @ 89.12
www.facebook.com/kb0177
|